Vulcan Construction Materials, LP (Board decision, March 2, 2011)
In re Vulcan Construction Materials, LP (EAB PSD Appeal No. 10-11): permit remanded for PM2.5, monitoring, and margin analysis
Apply this precedent to your situation
This is citable Board precedent from 2011, and it may have been appealed since. Ezel checks how it stands today and answers your situation, with citations.
Plain-English summary
The Illinois Environmental Protection Agency issued Vulcan Construction Materials, LP a PSD permit for renewed operation of a lime manufacturing plant in Manteno, Illinois. The Sierra Club challenged the permit's particulate-matter limits, preconstruction monitoring, NOx and carbon-monoxide limits, and the failure to apply a new one-hour nitrogen-dioxide standard. The EAB remanded the permit because the record did not sufficiently justify treating PM10 limits as BACT for PM2.5, using regional monitoring data, or including the NOx and CO compliance margins. The Board denied review of the new one-hour NO2 issue because the permit was issued before that standard took effect.
Decision snapshot
- Cited authorities: Clean Air Act sections 165 and 169, and 40 C.F.R. parts 50, 52, and 124, as cited in the official order.
- Outcome: The PSD permit was remanded for revised analysis, public comment, and further action.
- Key point: A PSD permit record must explain its PM2.5 surrogate, monitoring-data, and compliance-margin decisions well enough for public and Board review.
Full text (EPA EAB public release)
VULCAN CONSTRUCTION MATERIALS, LP 163
IN RE VULCAN CONSTRUCTION MATERIALS, LP
PSD Appeal No. 10-11
REMAND ORDER
Decided March 2, 2011
Syllabus
The Sierra Club asks the Environmental Appeals Board (“Board”) to review certain
conditions of a prevention of significant deterioration (“PSD”) permit the Illinois Environ- mental Protection Agency (“IEPA”) issued to Vulcan Construction Materials, Inc., LP (“Vulcan”) for renewed operation of a lime manufacturing plant (“Plant”) in Manteno, Kan- kakee County, Illinois. Resolution of the Sierra Club’s petition requires the Board to con- sider whether IEPA clearly erred in (1) determining that: (a) the permit’s best available control technology (“BACT”) emission limits for particulate matter measured as “PM10” also constitute BACT for particulate matter measured as “PM2.5”, or (b) the permit’s emis- sion limits for PM2.5 will comply with applicable National Ambient Air Quality Standards (“NAAQS”); (2) conducting the required PSD preconstruction monitoring and analysis by relying on regional monitoring data; (3) establishing emission limits for nitrogen oxide (“NOx”) and carbon monoxide (“CO”); and (4) failing to consider the new federal one-hour nitrogen dioxide (“NO2”) NAAQS.
Held: For the following reasons, the permit is remanded: (1) IEPA failed to provide
sufficient justification for concluding that the permit’s BACT limitations for PM10 also con- stitute BACT for PM2.5, and for concluding that the plant’s emissions of PM2.5 will comply with applicable NAAQS; (2) IEPA failed to provide sufficient justification for the use of regional data in conducting required preconstruction monitoring and analyses; and (3) IEPA failed to provide sufficient justification for the permit’s BACT limitations for NOx and CO. In particular, IEPA failed to justify either the inclusion of a margin of com- pliance for NOx or CO or the size of the margin.
On remand, IEPA must: (1) prepare a revised BACT analysis for PM2.5 and reopen
the public comment period to provide the public with an opportunity to review and com- ment on this analysis; (2) reevaluate whether the use of regional monitoring data was ap- propriate and reopen the public comment period to provide the public with an opportunity to review and comment ; and (3) either provide a sufficient rationale for including a com- pliance margin for NOx and CO, as well as the size of any such margins, or remove the compliance margins from the permit. Should IEPA choose to retain the compliance mar- gins, it must reopen the public comment period to provide the public with an opportunity to review and comment .
IEPA was not required to consider the new one-hour NO2 standard at the time the
permit was issued.
VOLUME 15
164 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
Before Environmental Appeals Judges Charles J. Sheehan,
Kathie A. Stein, and Anna L. Wolgast.
Opinion of the Board by Judge Stein:
I. STATEMENT OF THE CASE
The Sierra Club asks the Environmental Appeals Board (“Board”) to review
certain conditions of a revised Clean Air Act prevention of significant deteriora- tion (“PSD”) permit the Illinois Environmental Protection Agency (“IEPA”) issued to Vulcan Construction Materials, LP (“Vulcan”) for renewed operation of a lime manufacturing plant (“Plant”) in Manteno, Kankakee County, Illinois.1 Petition for Review and Request for Oral Argument (May 10, 2010) (“Petition”). Both IEPA and Vulcan responded that the Sierra Club has failed to demonstrate that review is warranted. See IEPA Response to Petition for Review (July 19, 2010) (“IEPA Response”); Vulcan’s Response to the Petition (June 14, 2010) (“Vulcan’s Re- sponse”).2 Finally, with the Board’s permission, the Sierra Club replied to both IEPA’s and Vulcan’s responses.3 See Petitioner’s Reply in Support (Aug. 19, 2010) (“Sierra Club’s Reply”).
II. ISSUES ON APPEAL
A. Issues Raised
Resolution of the Sierra Club’s petition requires the Board to address the
following four issues:
1. Has the Sierra Club demonstrated that IEPA clearly
erred in determining that: (a) the permit’s best available
control technology (“BACT”) emission limits for particu-
late matter measured as “PM10” also constitute BACT for
particulate matter measured as “PM2.5”; and (b) the per-
1 The Plant received its initial permit in 1996, but ceased operation in May 2003. See Respon-
siveness Summary for the Public Comment Period on a Revision to the Construction Permit/PSD Approval for Vulcan Construction Materials, LP for its Lime Kiln in Manteno, Illinois (April 2010) (“Response to Comments”) (Exhibit (“Ex.”) 6 to Petition) at 2; Project Summary for an Application for Revised Construction Permit/PSD Approval from Vulcan Construction Materials for its Lime Plant in Manteno, Illinois (“Project Summary”) at ¶ 3 & n.1.
2 See Order Granting [Vulcan’s] Motion to Participate and Respond to Petition for Review
(May 28, 2010).
3 See Order Granting Motion to File Reply (Aug. 25, 2010).
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 165
mit’s emission limits for PM2.5 will comply with applica-
ble National Ambient Air Quality Standards (“NAAQS”)?
2. Has the Sierra Club demonstrated that IEPA clearly
erred in conducting the required PSD preconstruction
monitoring and analysis by relying on regional monitor-
ing data?
3. Has the Sierra Club demonstrated that IEPA clearly
erred in establishing emission limits for nitrogen oxide
(“NOx”) and carbon monoxide (“CO”)? and
4. Has the Sierra Club demonstrated that IEPA clearly
erred in failing to consider the new federal one-hour nitro-
gen dioxide (“NO2”) NAAQS?
B. Parties’ Assertions on Appeal
The Sierra Club argues that IEPA made several errors in issuing the final
permit. In particular, the Sierra Club requests a remand for the following four reasons.
First, the Sierra Club argues that although the permit contains emissions
limitations for particulate matter measured as “PM10” (denoting particulates 10 mi- crometers or less in diameter), IEPA failed to comply with BACT requirements4 because the final permit does not also include a limitation on particulate matter measured as “PM2.5” (denoting particulates 2.5 micrometers or less in diameter).5
4 Permits must ensure compliance with emissions limits constituting BACT to minimize emis-
sions of regulated pollutants. CAA § 165(a)(4), 42 U.S.C. § 7475(a)(4); CAA § 169(3), 42 U.S.C.
§ 7479(3); 40 C.F.R. § 52.21(b)(23), (j)(2)-(3). BACT is defined, in part, as follows:
[BACT] means an emissions limitation (including a visible emission
standard) based on the maximum degree of reduction for each pollutant
subject to regulation under [the] Act which would be emitted from any
proposed major stationary source or major modification which the Ad-
ministrator, on a case-by-case basis, taking into account energy, environ-
mental, and economic impacts and other costs, determines is achievable
for such source or modification through application of production
processes or available methods, systems, and techniques, including fuel
cleaning or treatment or innovative fuel combustion techniques for con-
trol of such pollutant.
40 C.F.R. § 52.21(b)(12).
5 “Particulate matter is the generic term for a broad class of chemically and physically diverse
substances that exist as discrete particles (liquid droplets or solids) over a wide range of sizes.” Na-
Continued
VOLUME 15
166 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
Petition at 3-18. In addition, the Sierra Club argues that IEPA failed to satisfy its statutory obligation to demonstrate that emissions of PM2.5 would comply with applicable NAAQS and to allow for public comment on its analysis. Id. at 7-12. In response, both IEPA and Vulcan assert that the permit’s BACT provisions reg- ulating PM10 serve as an effective surrogate for limitations expressed in terms of PM2.5. See Vulcan’s Response at 11-20; IEPA Response at 5-9. That is, Vulcan and IEPA assert that BACT for PM10 also constitutes BACT for PM2.5. Vulcan and IEPA also maintain that the record includes a detailed analysis of the ambient air quality impacts from the plant and that this analysis concludes that particulate emissions would not result in a violation of the NAAQS for PM2.5. See Vulcan’s Response at 21-25; IEPA Response at 8-9.
Second, the Sierra Club argues that IEPA erred in conducting the required
PSD preconstruction monitoring analysis. Specifically, the Sierra Club asserts that IEPA failed to adequately analyze the ambient impacts of construction and opera- tion of the Plant because IEPA relied on regional monitoring data. According to the Sierra Club, IEPA failed to follow EPA guidelines for justifying the use of regional data. IEPA responds that it complied with applicable EPA guidance and that the Board should defer to IEPA’s expertise. IEPA Response at 9-13.
Third, the Sierra Club objects that the permit’s BACT limitations for CO
and NOx inappropriately provide for an excessive compliance margin. The permit establishes a BACT limit for CO of 11.48 pounds per ton of limestone feed (11.48 lb/ton) and a limit of 4.5 lb/ton for NOx. As the Sierra Club points out, however, prior stack testing during operation of the Plant in 1999 measured CO emissions of 4.76 lb/ton and NOx emissions of 3.45 lb/ton. Response to Com- ments at 69 nn.191 – 92. The Sierra Club argues that the record lacks any basis for increasing allowable emissions of CO by 240% and of NOx by 30%. Petition at 30-35. IEPA responds that the higher emission limits are necessary to allow for a margin of compliance to address variations in Plant operation. IEPA Response at 14-15. Similarly, Vulcan asserts that the permit issuer has discretion to include a “safety factor” to allow for fluctuations in emissions over an extended period of time. Vulcan’s Response at 38-45.
(continued)
tional Ambient Air Quality Standards for Particulate Matter, 62 Fed. Reg. 38,652, 38,653 (July 18, 1997). Particulates with an aerodynamic diameter of 10 micrometers or less is referred to as “PM10.” Id. at 38,653-54 n.1; see 40 C.F.R. § 50.6(c). PM10 is comprised of two principal fractions, referred to as “fine” and “coarse” particulate matter. 62 Fed. Reg. at 38,654. Fine particulate matter, labeled “PM2.5,” has an aerodynamic diameter of 2.5 micrometers or less, while coarse particulate matter has an aerodynamic diameter greater than 2.5 but less than or equal to 10 micrometers. Id. nn.5-6; see 40 C.F.R. § 50.7(a). The United States Environmental Protection Agency (“EPA”) has promulgated separate NAAQS for PM10 and PM2.5. See 40 C.F.R. §§ 50.6-.7.
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 167
Finally, the Sierra Club asserts that IEPA erred by failing to apply the
Agency’s recently-issued final rule establishing a new one-hour primary NAAQS for nitrogen dioxide (“NO2”). See Primary National Ambient Air Quality Stan- dards for Nitrogen Dioxide, 75 Fed. Reg. 6474 (Feb. 9, 2010). EPA issued the rule on February 9, 2010, with an effective date of April 12, 2010. Id. IEPA is- sued the final permit on April 9, 2010, three days before the rule’s effective date. In response, IEPA and Vulcan argue that the Sierra Club failed to preserve this issue for Board review because the issue was reasonably ascertainable but was not raised during the comment period on the draft permit. IEPA Response at 17; Vul- can’s Response at 45-51. In addition, IEPA and Vulcan assert that because the new NO2 standard was not in effect at the time IEPA issued the final permit, the new standard did not apply to this permit. IEPA Response at 17-18; Vulcan Re- sponse at 51-56.
III. SUMMARY OF DECISION
The Board concludes that the Sierra Club has met its burden of establishing
that IEPA clearly erred in its permit determination on the first three issues dis- cussed above. In particular, the Board holds that: 1) IEPA failed to provide suffi- cient justification for concluding that the permit’s BACT limitations for PM10 also constitute BACT for PM2.5, and for concluding that the plant’s emissions of PM2.5 will comply with applicable NAAQS; 2) IEPA failed to provide sufficient justifi- cation for the use of regional data in conducting required preconstruction monitor- ing and analyses; and 3) IEPA failed to provide sufficient justification for the permit’s BACT limitations for NOx and CO. With regard to the new one-hour primary NAAQS for NO2, the Board holds that IEPA did not clearly err in declin- ing to consider the new one-hour NO2 standard at the time the permit was issued.
IV. STANDARD OF REVIEW
Under the rules governing this proceeding, a PSD permit ordinarily will not
be reviewed unless it is based on a clearly erroneous finding of fact or conclusion of law, or involves an important matter of policy or exercise of discretion that warrants review. See 40 C.F.R. § 124.19(a); Consolidated Permit Regulations, 45 Fed. Reg. 33,290, 33,412 (May 19, 1980). The Board’s analysis of PSD per- mits is guided by the preamble to section 124.19, which states that the Board’s power of review “should be only sparingly exercised” and that “most permit condi- tions should be finally determined at the [permit issuer’s] level.” 45 Fed. Reg. at 33,412; accord In re Cardinal FG Co., 12 E.A.D. 153, 160 (EAB 2005). The burden of demonstrating that review is warranted rests with the petitioner, who must raise objections to the permit and explain why the permit issuer’s previous response to those objections is clearly erroneous or otherwise warrants review.
VOLUME 15
168 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
In re BP Cherry Point, 12 E.A.D. 209, 217 (EAB 2005); In re Steel Dynamics, Inc., 9 E.A.D. 740, 744 (EAB 2001).
V. PROCEDURAL AND FACTUAL HISTORY
On October 27, 2003,6 Vulcan applied for a PSD permit to commence oper-
ation of an existing (but inactive) lime manufacturing plant in Manteno, Kankakee County, Illinois. The Plant consists of a rotary lime kiln with the capacity to pro- duce 600 tons of lime per day and is designed to burn solid fuel (coal and petro- leum coke). Project Summary (Ex. 5 to Petition) at 1. The principal source of emissions from the Plant is the kiln. Id. These emissions include particulate mat- ter, sulfur dioxide, NOx, and CO.
On April 17, 2009, IEPA issued a draft permit for the Plant and made the
draft available for public review and comment. Id. at 1. IEPA also held a public hearing on the draft permit on June 4, 2009. IEPA issued its final permit determi- nation on April 9, 2010 (see Construction Permit – PSD Approval – Revised NSPS Source (Apr. 9, 2010) (“Final Permit”)), along with the Response to Com- ments. As stated above, the Petition was filed on May 9, 2010. The Board held oral argument in this matter on December 14, 2010, at which the Sierra Club, IEPA, and Vulcan participated.
VI. ANALYSIS
A. Relevant Statutory and Regulatory Provisions
The Clean Air Act’s PSD program regulates air pollution in areas of the
country deemed to be in “attainment” or “unclassifiable” with respect to the NAAQS. See CAA §§ 161, 165, 42 U.S.C. §§ 7471, 7475. NAAQS are “maxi- mum concentration ‘ceilings’ measured in terms of the total concentration of a pollutant in the atmosphere.” Office of Air Quality Planning and Standards, U.S. EPA, New Source Review Workshop Manual at C.3 (draft Oct. 1990) (“NSR Manual”).7 Congress charged EPA with developing NAAQS for air pollutants
6 The record before the Board does not contain a clear explanation for the approximately
6-year lag between Vulcan’s permit application and IEPA’s issuance of the draft permit.
7 The NSR Manual has been used as a guidance document in conjunction with new source
review workshops and training and as a guide for state and federal permitting officials with respect to PSD requirements and policy. Although it is not a binding Agency regulation, the Board has looked to the NSR Manual as a statement of the Agency’s thinking on certain PSD issues. E.g., In re Co- nocoPhillips Co., 13 E.A.D. 768, 772 (EAB 2008); In re RockGen Energy Ctr., 8 E.A.D. 536, 542 n.10 (EAB 1999); In re Knauf Fiber Glass, GmbH, 8 E.A.D. 121, 129 n.13 (EAB 1999).
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 169
whose presence in the atmosphere in excess of certain concentration levels could “reasonably be anticipated to endanger public health or welfare.”8 CAA
§ 108(a)(1)(A), 42 U.S.C. § 7408(a)(1)(A); see CAA § 109, 42 U.S.C. § 7409. In geographical areas deemed to be in “attainment” for any of these pollutants, the ambient air quality meets the NAAQS for that pollutant. CAA § 107(d)(1)(A)(ii), 42 U.S.C. § 7407(d)(1)(A)(ii). In areas designated as “unclassifiable,” air quality cannot be classified on the basis of available information as meeting or not meet- ing the NAAQS. CAA § 107(d)(1)(A)(iii), 42 U.S.C. § 7407(d)(1)(A)(iii).9 Par- ties who wish to construct “major emitting facilities”10 in attainment or unclassifi- able areas must obtain preconstruction approval in the form of PSD permits to build such facilities. CAA § 165, 42 U.S.C. § 7475.
As part of the permit issuance process, the PSD regulations at 40 C.F.R.
§ 52.21 require, among other things, that new major stationary sources of air pol- lution, and any major modification of such sources, be carefully reviewed prior to construction to ensure that emissions from such facilities will not cause an ex- ceedance of the NAAQS or applicable PSD ambient air quality “increments.”11 These permits must also require compliance with emissions limits constituting BACT to minimize emissions of regulated pollutants.12 CAA § 165(a)(4), 42 U.S.C. § 7475(a)(4); 40 C.F.R. § 52.21(b)(23), (j)(2)-(3).
When PSD permits are issued by a state pursuant to a delegation of the
federal PSD program, as is the case here, such permits are considered EPA-issued permits and, therefore, are subject to administrative appeal to the Environmental Appeals Board (“Board”) in accordance with 40 C.F.R. § 124.19. IEPA adminis- ters the PSD program in Illinois pursuant to a delegation of authority from U.S. EPA Region 5 (the “Region”). See Prevention of Significant Deterioration Delegation of Authority to State Agencies, 46 Fed. Reg. 9580 (Jan. 29, 1981)
8 NAAQS have been established for six criteria pollutants: sulfur dioxide, particulate matter,
nitrogen dioxide, carbon monoxide, ozone, and lead. See 40 C.F.R. §§ 50.4 – 50.13.
9 Areas may also be designated as “nonattainment,” meaning that the concentration of a pollu-
tant in the ambient air does not meet the NAAQS for that pollutant. CAA § 107(d)(1)(A)(i), 42 U.S.C.
§ 7407(d)(1)(A)(i). The PSD program is not applicable, however, in non-attainment areas. See CAA § 161, 42 U.S.C. § 7471.
10 A “major emitting facility” is a stationary source in any of certain listed stationary source
categories that emits or has the “potential to emit” 100 tons per year (“tpy”) or more of any air pollu- tant, or any other source that has the potential to emit 250 tpy or more of any air pollutant. See CAA
§ 169(1), 42 U.S.C. § 7479(1).
11 A PSD “increment” refers to “the maximum allowable increase in concentration that is al-
lowed to occur above a baseline concentration for a pollutant.” NSR Manual at C.3; see also 40 C.F.R.
§ 52.21(c) (setting forth increments for regulated pollutants).
12 See supra, note 4.
VOLUME 15
170 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
(setting forth Delegation Agreement between State of Illinois and U.S. EPA); In re Zion Energy, LLC, 9 E.A.D. 701, 701 n.1 (EAB 2001).
B. Issues Analyzed
1. Has the Sierra Club Demonstrated That IEPA Clearly Erred in
Its Determination That (a) the Permit’s BACT Emission
Limitations for PM10 Also Constitute BACT for PM2.5 and (b) the
Plant’s Emission of PM2.5 Will Comply With Applicable NAAQS?
a. PM2.5 BACT Analysis
As mentioned above, the Act and EPA PSD regulations make major new
stationary sources and major modifications, such as the Plant at issue in this case, subject to BACT for emissions of certain pollutants. CAA § 165(a)(4), 42 U.S.C.
§ 7375(a)(4); 40 C.F.R. § 52.21(j)(2). The NSR Manual sets forth a “top-down” process for determining BACT for a particular regulated pollutant. The process includes the following five steps: (1) identify all available control options for a targeted pollutant; (2) analyze the control options’ technical feasibility; (3) rank feasible options in order of effectiveness; (4) evaluate energy, environmental, and economic impacts; and (5) select BACT and establish a pollutant emission limit achievable by the most effective control option not eliminated in a preceding step.13 NSR Manual at B.5-.9; see In re Northern Mich. Univ., 14 E.A.D. 283, 292-94 (EAB 2009) (explaining the steps in top-down analysis).
In its comments on the draft permit, the Sierra Club argued that even though
EPA established NAAQS for PM2.5 in 1997, IEPA failed to conduct a top-down BACT analysis for emissions of PM2.5 in accordance with the above-mentioned procedures, or to include an appropriate PM2.5 BACT limitation in the permit. See Letter from James P. Gignac, Sierra Club, to Dean Studer, IEPA, Comments on Draft Prevention of Significant Deterioration Construction Permit for Vulcan Construction Materials, at 30 (July 22, 2009) (“Sierra Club Comments”) (citing National Ambient Air Quality Standards for Particulate Matter, 62 Fed. Reg. 38,652 (July 18, 1997) (codified as amended at, inter alia, 40 C.F.R.
§ 50.7)). In responding to these comments, IEPA did not dispute that, in preparing the draft permit, IEPA did not conduct a top-down BACT analysis for PM2.5 emis- sions or establish a BACT limit for PM2.5. Rather, IEPA determined that BACT for PM10 could serve as a surrogate for BACT for PM2.5. In its Petition, the Sierra Club again asserts that IEPA erred by failing to conduct a PM2.5-specific BACT
13 Although the top-down analysis is not a mandatory methodology, it is frequently used by
permitting authorities to ensure that a defensible BACT determination, involving consideration of all requisite statutory and regulatory criteria, is reached. Northern Mich. Univ., 14 E.A.D. at 291-92; In re Steel Dynamics, Inc., 9 E.A.D. 165, 183 (EAB 2000); Knauf, 8 E.A.D. at 129 n.14, 134 n.25.
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 171
analysis or to include a BACT emissions limitation for PM2.5. See Petition at 3-18. Upon review, the Board concludes that IEPA has failed to provide sufficient sup- port for its determination that the permit’s BACT requirements for PM10 also con- stitute BACT for PM2.5.
EPA released a policy memorandum affecting BACT determinations for
PM2.5 in October of 1997, just a few months after EPA promulgated the PM2.5 NAAQS.14 See Memorandum from John S. Seitz, Director, Office of Air Quality Planning & Standards, U.S. EPA, to Regional Air Directors, Interim Implementa- tion of New Source Review Requirements for PM2.5 (Oct. 23, 1997) (“Seitz Memo- randum”). The Seitz Memorandum established what is referred to as the “Surro- gate Policy,” which authorized the interim use of PM10 as a “surrogate” for PM2.5 in meeting the PSD requirements because of “significant technical difficulties” at- tending full implementation of PSD requirements for PM2.5, largely resulting from a lack of adequate tools for calculating PM2.5 emissions. Id. at 1-2. EPA later reaffirmed the Surrogate Policy in April 2005, noting that the Agency had not yet promulgated an implementation rule for PM2.5 and thus administration of PSD requirements for PM2.5 emissions remained “impractical.” Memorandum from Ste- phen D. Page, Director, Office of Air Quality Planning & Standards, U.S. EPA, to Regional Offices, Implementation of New Source Review Requirements in PM-2.5 Nonattainment Areas, at 4 (Apr. 5, 2005).
On May 16, 2008, EPA promulgated a final rule entitled “Implementation of
the New Source Review (NSR) Program for Particulate Matter Less than 2.5 Mi- crometers (PM2.5)” to implement the new source review program for fine particu- late matter. 73 Fed. Reg. 28,321 (May 16, 2008) (“2008 Implementation Rule”). The preamble to the 2008 Implementation Rule explains that the technical diffi- culties in calculating PM2.5 emissions have now been largely resolved, which eliminated, in large part, the basis for using PM10 as a surrogate for PM2.5 as per- mitted by the Surrogate Policy. See 73 Fed. Reg. at 28,340. The final rule, how- ever, contained a delayed implementation process (referred to as the “grandfather- ing provision”) allowing the Surrogate Policy to continue to apply to facilities in delegated states with completed and pending permit applications.15 See id. The permit application in this matter was pending when the 2008 Implementation Rule was issued. Thus, during the draft permitting stage, IEPA, in reliance on the Sur-
14 The PM
2.5 NAAQS were challenged by numerous litigants and in May 1999, the U.S. Court
of Appeals for the D.C. Circuit remanded, but did not vacate, the standards. Am. Trucking Assocs., Inc. v. U.S. EPA, 175 F.3d 1027, 1047-48, on reh’g, 195 F.3d 4 (D.C. Cir. 1999). Subsequently, the Su- preme Court upheld the PM2.5 standards. Whitman v. Am. Trucking Assocs. Inc., 531 U.S. 457 (2001). In March 2002, the D.C. Circuit rejected all remaining challenges to the PM2.5 standards. Am. Trucking Assoc. v. U.S. EPA, 283 F.3d 355 (D.C. Cir. 2002).
15 The grandfathering provision was codified at 40 C.F.R. § 52.21(i)(l)(xi).
VOLUME 15
172 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
rogate Policy, substituted a PM10 BACT analysis for the PM2.5 BACT analysis.16
Following issuance of the draft permit, however, EPA, on June 1, 2009,
stayed the grandfathering provision. See 74 Fed. Reg. 26,098 (June 1, 2009) (stay- ing grandfathering provision until Sept. 1, 2009); 74 Fed. Reg. 48,153 (Sept. 22, 2009) (extending stay of grandfathering provision until June 22, 2010).17 Pursuant to the stay, reliance on the Surrogate Policy was no longer authorized for permit applications pending after the effective date of the 2008 Implementation Rule. This stay was in effect at the time IEPA issued its final permit decision on April 9, 2010. Thus, even if IEPA appropriately relied on BACT for PM10 as a surrogate for BACT for PM2.5 in preparing the draft permit, it was not appropriate to rely on the Surrogate Policy at the time IEPA issued the final permit.
In its response to comments, IEPA purports to conduct a BACT analysis for
PM2.5. See Response to Comments at 40 (stating that IEPA conducted an assess- ment of PM2.5 impacts due to the stay of the grandfathering provision);18 see also Vulcan’s Response at 21 (stating that IEPA conducted a BACT analysis for PM2.5 in its Response to Comments). The analysis in IEPA’s Response to Comments, however, continues to rely on the conclusion that PM10 can serve as a surrogate for PM2.5. See Response to Comments at 37 (stating that the proposed Plant is an ideal situation in which to rely on surrogacy in establishing BACT for PM2.5). As stated above, as a result of the stay of the grandfathering provision, permit appli- cants and issuers were not authorized to rely on PM10 as an appropriate surrogate for PM2.5. Thus, it is not clear to this Board why IEPA nevertheless relied on a surrogacy analysis.19
16 The grandfathering provision applies only in situations where a source submitted a com-
pleted application by July 15, 2008, and the permit issuer “determines that the application was com- plete as submitted.” 73 Fed. Reg. at 28,340. As stated above, the application for this permit was sub- mitted on October 27, 2003. However, the record in the present case does not contain any documentation regarding the completeness of Vulcan’s permit application. That is, nothing in the re- cord indicates that IEPA made a determination that Vulcan’s permit application was complete as of July 15, 2008. Indeed, IEPA conceded during oral argument that the record did not contain any such documentation. See EAB Oral Arg. Tr. at 30.
17 Last year EPA proposed repealing the grandfathering provision for PM . See Implementa-
2.5
tion of NSR Program for [PM2.5], 75 Fed. Reg. 6,827 (Feb. 11, 2010). At the time of this decision, that proposed rule has not been finalized.
18 Although this assessment is titled “Assessment of PM
2.5 Air Quality Impacts,” see Response
to Comments at 40 n.102, IEPA stated at oral argument that the assessment was also intended to address BACT compliance. See Oral Arg. Tr. (Dec. 14, 2010) at 32.
19 See Vulcan Response at 13 -14 (“In this instance, IEPA determined, through its analysis of
the emissions projected to result from the Project performed in accordance with the PM10 surrogate policy and the general principles and practices with respect to reliance on surrogate pollutants, that the limits included in the Permit appropriately control PM2.5 emissions expressed as PM.”)
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 173
Further, even if a surrogacy analysis were appropriate in this case, the Re-
sponse to Comments does not contain the degree of specificity necessary to sup- port the conclusion that PM10 serves as an appropriate surrogate for PM2.5 emis- sions. See, e.g., In re Louisville Gas and Electric Co., Petition No. IV-2008-3 (Order Responding to Issues Raised in April 28, 2008 and March 2, 2006 Petition, and Denying in Part and Granting in Part Requests for Objection to Permit) (Adm’r Aug. 12, 2009).20 In Louisville Gas, the Administrator stated that, in order to justify the use of a surrogacy analysis, permit applicants and issuers must demonstrate that PM10 is a reasonable surrogate for PM2.5. Id. at 43-46. That dem- onstration must address, among other things, the differences between PM10 and PM2.5 and must include a detailed and well-supported analysis of why PM10 is nevertheless an adequate surrogate. Id. The Louisville Gas decision also discusses possible approaches for conducting this analysis. See id. at 45-46. For example, the Administrator suggests the following approaches for demonstrating surrogacy:
First, the source or the permitting authority establishes in
the permit record a strong statistical relationship between
PM10 and PM2.5 emissions from the proposed unit, both
with and without the proposed control technology in oper-
ation. Without a strong correlation, there can be little con-
fidence that the statutory requirements will be met for
PM2.5 using the controls selected through a PM10 NSR
analysis.
Id. at 45. In the alternative, the source or permitting authority could demonstrate:
that the degree of control of PM2.5 by the control technol-
ogy selected in the PM10 BACT analysis will be at least as
effective as the technology that would have been selected
if a BACT analysis specific to PM2.5 emissions had been
conducted. We present here two possible paths to accom-
plish this. This first would be to perform a PM2.5-specific
BACT analysis, in which case the requirement is met if
the control technology selected through the PM10 BACT
analysis is physically the same as what is selected through
the PM2.5 BACT analysis, in all respects that may affect
control efficiency for PM2.5. The second path would be to
perform a PM2.5-specific BACT analysis, and show that
while the type and/or physical design of the control tech-
nology may be different, the efficiency for PM2.5 control
of the technology selected through the PM10 BACT analy-
20 The Louisville Gas decision is available at the following URL:
http://www.epa.gov/region7/air/title5/petitiondb/petitions/lg_e_2nddecision2006.pdf.
VOLUME 15
174 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
sis is equal to or better than the efficiency of the technol-
ogy selected through the PM2.5 BACT analysis, across the
range of operating conditions that can be anticipated for
the source and the control equipment. This demonstration
may be based on engineering review and/or old or new
emissions test data from units and control equipment sim-
ilar to the proposed unit with the proposed control
equipment.
Id. at 45-46. Although, as the Administrator made clear, these steps were not in- tended as an exhaustive list of the methods for demonstrating surrogacy, permit issuers should conduct a careful analysis of “the case law and the limits of the Surrogate Policy to determine what information and analysis would need to be included in the permit application and record before relying on the Surrogate Pol- icy.” Id. at 46.
IEPA’s BACT analysis falls considerably short of the Louisville Gas bench-
mark. The analysis here contains only unsupported conclusory assertions that sur- rogacy is appropriate because “for the kiln and other process units that are con- trolled with filters, * * * the PM limits require proper operation of the filters, which are the ‘best devices’ for control of fine particulates * * * . For other oper- ations that are controlled by work practices, [surrogacy is appropriate] because requirements reflect ‘best practices’ for emissions of PM, PM10 and PM2.5.” Re- sponse to Comments at 37. Such assertions, in the absence of concrete details, record support, and further comparison and analysis, are insufficient to support IEPA’s conclusion that PM2.5 emissions are “most appropriately set in terms of PM.” See Response to Comments at 39.
As this Board has stated, BACT determinations are one of the most critical
elements in the PSD permitting process, must reflect the considered judgment on the part of the permit issuer, and must be well documented in the administrative record. See In re Desert Rock Energy Co., LLC, 14 E.A.D. 484, 520 (EAB 2009); Knauf, 8 E.A.D. at 132; accord In re Newmont Nev. Energy Inv., LLC, 12 E.A.D. 429, 442 (EAB 2005); In re Gen. Motors, Inc., 10 E.A.D. 360, 363 (EAB 2002). Because the record before the Board is insufficient to support IEPA’s BACT de- termination for PM2.5, the permit is remanded on this issue.
On remand, IEPA is ordered to prepare a revised BACT analysis for PM2.5
and to reopen the public comment period to provide the public with an opportu- nity to review and comment on this analysis. As indicated above, the stay of the grandfathering provision was in effect at the time the final permit was issued. However, that stay has now expired. See Implementation of the [NSR] Program for [PM2.5], 74 Fed. Reg. 48,153 (Sept. 22, 2009) (extending stay of grandfather- ing provision until June 22, 2010). Although EPA has proposed a repeal of the grandfathering provision, that repeal has not yet been finalized. On remand, if
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 175
applicable rules allow IEPA to continue to rely on a surrogacy analysis, IEPA must, consistent with the Administrator’s decision in Louisville Gas, provide a sufficient, detailed, and well-supported basis for its conclusion that, in the particu- lar circumstances of this permit, PM10 is a reasonable proxy for PM2.5. If applica- ble rules prevent IEPA from relying on such an analysis, IEPA must conduct an adequate top-down BACT analysis for PM2.5. In either case, IEPA must reopen the public comment period. In the interim, the Board suggests that IEPA consult with EPA as to the anticipated timing for final action on the proposed repeal of the grandfathering provision and whether EPA anticipates that parties will be able to continue to rely on existing surrogacy guidance.
b. Ambient Air Quality Analysis
As stated above, applicants for PSD permits must, among other things,
demonstrate, through analysis of the anticipated air quality impacts associated with their proposed facilities, that their facilities’ emissions will not cause or con- tribute to an exceedance of any applicable NAAQS or air quality increment.21 See CAA § 165(a)(3), 42 U.S.C. § 7475(a)(3); 40 C.F.R. § 52.21(k)-(m). In its com- ments on the draft permit, the Sierra Club asserted that IEPA had failed to under- take the necessary modeling and analysis to demonstrate that the permit’s emis- sions limits would ensure compliance the PM2.5 NAAQS. See Response to Comments at 39. In response to this comment, IEPA stated that it “has assessed the impact on PM2.5 air quality, using the results from the analysis for PM10 im- pacts.” Id. at 39-40. IEPA states that “this assessment became necessary when
[EPA] stayed the grandfathering provision of the PSD rules for PM2.5.” Id. at 40. IEPA states that “[t]his assessment shows that the plant would not result in ex- ceedances of the PM2.5 NAAQS.” Id. (footnote omitted). The Response to Com- ments includes a footnote purporting to show the results of this assessment. See id. at 40 n.102.
On appeal, the Sierra Club asserts that IEPA failed to conduct its ambient
air quality analysis prior to the close of the comment period. Petition at 9. Further, the Sierra Club argues that the model used in the PM2.5 analysis is not clear from IEPA’s response to comments and was not specified with “reasonable particular- ity” as required by the Act. Id. (quoting CAA § 165(e)(3)(D), 42 U.S.C.
§ 7475(e)(3)(D)).
As this Board has previously stated, “Congress has determined that the air
quality analysis required by the regulations ‘shall be available at the time of the public hearing on the application for such permit.’” In re Hawaii Elec. Light Co.,
21 The PSD regulations identify the overall maximum allowable incremental increase in the
ambient concentration of each pollutant that may occur in any attainment or unclassifiable area as a result of new or modified major emitting facilities. 40 C.F.R. § 52.21(c).
VOLUME 15
176 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
Inc, 8 E.A.D. 66, 102 (EAB 1998) (“HELCO”) (quoting CAA § 165(e)(3)(c), 42 U.S.C. § 7475(e)(3)(c)). Thus, in HELCO, this Board remanded a permit to the permit issuer for preparation of an updated air quality impact report followed by notice and comment where data relevant to the impact analysis was not subject to the public scrutiny contemplated by the statute and applicable regulations. Id. at 102-103. In this case, the entire impact analysis was prepared after the close of the comment period and was not subject to public comment. Moreover, IEPA’s response to comments provides only a cursory explanation of how the analysis was conducted. Under these circumstances, the permit is remanded to IEPA. On remand, IEPA must make the ambient air quality analysis for PM2.5 available to the public,22 and provide the public with the opportunity to submit comments.
2. Has the Sierra Club Demonstrated That IEPA Clearly Erred in
Conducting the Required Preconstruction Monitoring and
Analysis by Relying on Regional Monitoring Data?
As stated above, the regulations governing issuance of PSD permits require
that new major stationary sources of air pollution, and major modification of such sources, be carefully reviewed prior to construction to ensure that emissions from such facilities will not cause an exceedance of the NAAQS or applicable PSD ambient air quality increments. 40 C.F.R. § 52.21. The CAA and implementing regulations require PSD permit applicants to collect and submit twelve months of ambient air quality monitoring data for the year preceding the date of permit ap- plication, showing pollutant concentrations at the site of the proposed facility and in areas that may be affected by emissions from that facility. CAA § 165(a)(7), (e), 42 U.S.C. § 7475(a)(7), (e); 40 C.F.R. § 52.21(m). These data may then be used, in conjunction with other information, to demonstrate the facility’s compli- ance with the NAAQS and PSD increments. See NSR Manual at C.16-.21.
While site-specific data is generally required to demonstrate compliance
with the NAAQS and PSD increments, longstanding Agency guidance provides for a waiver of this requirement where existing ambient data are deemed suffi- ciently representative of air quality in the targeted area – in terms of the suffi- ciency of the monitoring locales selected and the quality and currentness of the monitoring data – to legitimately be substituted for site-specific data. See NSR Manual at C.18-.19; Office of Air Quality, U.S. EPA, Ambient Monitoring Guide- lines for Prevention of Significant Deterioration (PSD) § 2.4, at 6-9 (May 1987)
[hereinafter Ambient Monitoring Guidelines]; see also, e.g., In re Knauf Fiber Glass, GmbH, 8 E.A.D. 121, 145-48 (EAB 1999); HELCO, 8 E.A.D. at 97-105; In re Hibbing Taconite Co., 2 E.A.D. 838, 850-51 (Adm’r 1989). The EAB and its predecessors have consistently followed this guidance. See, e.g., Northern Mich.
22 IEPA’s ambient air quality analysis must meet all applicable statutory and regulatory
requirements.
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 177
Univ., 14 E.A.D. at 328; Knauf, 8 E.A.D. at 145-48; HELCO, 8 E.A.D. at 97-105; Hibbing, 2 E.A.D. at 850-52.
In its comments on the draft permit, the Sierra Club objected to the use of
existing regional monitoring data rather than site-specific data to satisfy this re- quirement. Although the Sierra Club acknowledged that the Agency guidance al- lows for the use of regional monitoring data under certain circumstances, see NSR Manual at C.16-C.19 (summarizing conditions under which regional data may be used and referencing the Ambient Monitoring Guidelines as a source of additional guidance), the Sierra Club asserted that the reliance on regional data was inappro- priate in this case. See Sierra Club Comments at 41-45. In particular, the Sierra Club asserted that the monitoring data used in this case, obtained from monitors located 20-25 miles from the Plant, were not appropriate for the preconstruction ambient air quality analysis because they were not representative of the air quality for the area in which the facility would be constructed and operated.23 Id. The Sierra Club also argued that the regional data failed to meet the same quality stan- dards required of on-site monitoring such as continuous instrument monitoring and documented quality control. Id. at 44.24
The Ambient Monitoring Guidelines provides three examples of when the
use of regional monitoring data may be appropriate. The Guidelines state, in part:
In situations where there is no existing monitor in the
modeled areas, monitors located outside these three types
of areas may or may not be used. Each determination
must be made on a case-by-case basis. In order to clarify
EPA’s intent regarding the use of existing monitoring
23 IEPA states that the monitoring data was taken from monitors at three locations: Braidwood,
Joliet, and Midlothian. Response to Comments at 75.
24 The Sierra Club references the Ambient Monitoring Guidelines’ data quality requirements.
Ambient Monitoring Guidelines at 8. Those requirements state that monitoring data must be of similar quality as that obtained with site-specific monitoring and that “[a]s a minimum, this would mean:
1. The monitoring data were collected with continuous instrumentation.
* * * [and]
2. The applicant should be able to produce records of the quality control
performed during the time period at which the data were collected. Such
quality control records should include calibration, zero and span checks,
and control checks. In addition, quality control procedures should be a
minimum specified in the instrument manufacturer’s operation and in-
struction manual.
Id.
VOLUME 15
178 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
data, some examples are included to demonstrate the
overall intent.
(a) Case I – If the proposed source or modification will be
constructed in an area that is generally free from the im-
pact of other point sources and area sources associated
with human activities, then monitoring data from a “re-
gional” site may be used as representative data. Such a
site could be out of the maximum impact area, but must
be similar in nature to the impact area. This site would be
characteristic of air quality across a broad region includ-
ing that in which the proposed source or modification is
located. The intent of EPA is to limit the use of these “re-
gional” sites to relatively remote areas, and not to use
them in areas of multisource emissions or areas of com-
plex terrain.
(b) Case II – If the proposed construction will be in an
area of multisource emissions and basically flat terrain,
then the proposed source or modification may propose the
use of existing data at nearby monitoring sites if either of
the following criteria are met.
1. The existing monitor is within 10 km of the
points of proposed emissions, or
2. The existing monitor is within or not far-
ther than 1 km away from either the area(s) of
the maximum air pollutant concentration from
existing sources or the area(s) of the com-
bined maximum impact from existing and
proposed sources.
* * *
(c) Case III – If the proposed construction will be in an
area of multisource emissions and in areas of complex ter-
rain, aerodynamic downwash complications, or
land/water interface situations, existing data could only be
used for PSD purposes if it were collected (1) at the
modeled locations(s) of the maximum air pollution con-
centration from existing sources, (2) at the location(s) of
the maximum concentration increase from the proposed
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 179
construction, and (3) at the location(s) of the maximum
impact area.
Ambient Monitoring Guidelines § 2.4.1, at 6-8.
In response to the Sierra Club’s comments on this issue, IEPA stated that
Illinois operated monitoring stations in the “general region” of the proposed Plant and that data from these locations made on-site preconstruction monitoring unnec- essary. Response to Comments at 70-71.
This is because of the nature of Illinois’ ambient monitor-
ing network. Ambient monitoring stations are sited to pro-
vide representative data for air quality in Illinois, as
needed to support air quality planning and management in
Illinois. These stations are also operated in accordance
with quality assurance procedures so as to collect accurate
data that can properly be relied upon for these purposes.
Response to Comments at 72 (footnotes omitted). In responding to comments stat- ing that IEPA had failed to meet the criteria for the above-quoted Case II example in the Ambient Monitoring Guidelines, IEPA concluded that this case fits more appropriately into the Case I scenario. IEPA stated:
The proposed plant is more appropriately addressed as if
its situation is that addressed by Case I in the Ambient
Monitoring Guidelines, not Case II * * *. Case I ad-
dresses the situation where a proposed project is located
in an area that is generally free from the impact of other
point sources and area sources associated with human ac-
tivities. In this situation, monitoring data from a regional
monitor, which may be characteristic of air quality across
the region, may be used as representative data.
* * *
[T]he ambient monitoring stations used to provide back-
ground concentrations meet the relevant location criteria
of the Ambient Monitoring Guidelines. The fact that these
monitors are some distance from Manteno does not pre-
clude their use. Indeed, it is consistent with the fact that
they are regional monitors, which were sited to collect
monitoring data for northeastern Illinois, focusing on air
quality in the Greater Chicago Metropolitan Area, where
industry and population are concentrated.
VOLUME 15
180 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
The acceptance of data from the selected monitoring sta-
tions as suitable for the air quality analyses for the pro-
posed plant reflects the Illinois EPA’s knowledge of air
quality in Northeastern Illinois and the character of the
particular areas surrounding each monitoring station. The
Braidwood monitor is at a site that is very similar to
Manteno, as it is an agricultural area is [sic] which air
quality is determined either by general background air
quality, when the wind is toward the Chicago area, or ur-
ban transport, when the wind is coming from the Chicago
Area. The Joliet monitor is at a site that is significantly
more developed than the Manteno area, being in an indus-
trial area on the edge of Joliet, an industrial-suburban city
with a population of about 150,000 in the Greater Chicago
Area. The Midlothian monitor is about 15 miles south of
the Chicago loop, in an area that is significantly more de-
veloped than Manteno, in a community with a population
of about 15,000. Given the character of Joliet and Midlo-
thian, data from these monitoring stations in these com-
munities are a conservative representation of background
air quality in Manteno, which is likely significantly lower
than measured at these stations.
Response to Comments at 74-75 (footnote omitted).25 For these reasons, IEPA concluded that data from existing regional locations were sufficiently representa- tive of the project site and were gathered in a manner sufficient to satisfy EPA requirements. Id. at 72.
On appeal, the Sierra Club again argues that IEPA erroneously relied on
regional monitoring data because these data are not representative of air quality at the site. See Petition at 19-30. In particular, the Sierra Club points out that Agency policy allows data from off-site monitors to be used if those data represent the locations of: (a) maximum concentration increase from the proposed facility; (b) maximum air pollutant concentration from existing sources; and (c) maximum combined impact area (existing sources plus proposed facility). Petition at 21 (cit- ing Ambient Monitoring Guidelines § 2.4.1, at 6-8; Hibbing Taconite, 2 E.A.D. at 850-51). The Sierra Club argues that IEPA’s responses to comments on this issue are conclusory in nature and, to the extent that IEPA has developed a suffi-
25 With regard to the quality of the data, IEPA stated that “Illinois’s ambient monitoring net-
work is operated to meet the applicable ‘quality requirements’ for ambient monitoring. This is a neces- sary aspect of the operation of this network, as collected data is relied upon for designations of attain- ment and nonattainment, development of attainment strategies, and general air quality planning. Compliance with these quality requirements is confirmed by periodic audits conducted by [EPA].” Response to Comments at 76 (footnote omitted).
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 181
cient record on this issue, the record contradicts IEPA’s conclusions. Petition at 28-30. In particular, the Sierra Club argues that the record does not support IEPA’s reliance on the “Case I” example provided in the Ambient Monitoring Guidelines for facilities located in areas that are “generally free from the impact of other point sources and area sources associated with human activities.” Id. at 29 (quoting Ambient Monitoring Guidelines § 2.4.1, at 6). The Sierra Club points out that the record shows the presence of several other point sources in the vicinity of the Plant and that IEPA recognized the existence of these sources in the Statement of Basis. Id. The Sierra Club asserts that, under these circumstances, this Board should review and remand the permit to IEPA.
Upon review of the record, the Board concludes that IEPA has failed to
demonstrate that IEPA’s use of regional monitoring data was appropriate in this case.
As stated above, the Ambient Monitoring Guidelines provide three exam-
ples of situations where the use of regional monitors may be appropriate (desig- nated as “Case I,” “Case II,” and “Case III”). Ambient Monitoring Guidelines
§ 2.4.1, at 6-7.26 IEPA determined that the use of regional monitoring data was appropriate because the Plant met the criteria described in Case I of the monitor- ing guidelines.27 IEPA’s entire justification for this determination, however, ap- pears in one paragraph in IEPA’s Response to Comments. Specifically, in re- sponding to the Sierra Club’s assertion that the Plant was located in an area with multiple sources and should therefore be subject to the Case II criteria, IEPA re- sponded, in relevant part, that:
26 The Ambient Monitoring Guidelines state that these examples “are included to demonstrate
the overall intent” of the guidelines and that each determination must be made on a case-by-case basis. Ambient Monitoring Guidelines § 2.4.1 at 6. While this suggests that these examples are not an ex- haustive description of circumstances under which permit issuers may approve the use of regional data, where, as here, the record indicates that the permit issuer relied on one of these examples in determining that the use of such data was appropriate, this Board will closely examine whether the record supports this determination. See Ash Grove Cement Co., 7 E.A.D. 387, 417-18 (EAB 1992) (explaining that the Board will review permit determinations based on the methods articulated by the permit issuer).
27 In its Response to Comments, IEPA states that “based on the regulatory discussion of back-
ground concentrations in Section 8.2 of the Guidelines on Air Models, 40 CFR [part] 51, Appendix W, it is not clear that regional monitoring is subject to the criteria referred to” in the Ambient Monitoring Guidelines. Response to Comments at 74. To the extent that IEPA is suggesting that the use of re- gional data would have been appropriate in this case even if the criteria in the Ambient Monitoring Guidelines had not been satisfied, IEPA’s assertion is unsupported by the record. In any case, the record shows that in making its determination regarding the use of regional monitoring data, IEPA relied on the above-quoted Case I criteria in the Ambient Monitoring Guidelines. Response to Com- ments at 74; IEPA Response at 12 (stating that the use of the Case I scenario was appropriate). Thus, this Board will review this issue based on the strength of the record that IEPA compiled. See Ash Grove Cement, 7 E.A.D. at 417-18.
VOLUME 15
182 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
[w]hile there are some sources in the vicinity of the pro-
posed project site, their impacts are more than adequately
addressed by the combination of the selected background
monitors and modeling of existing point sources. The pro-
posed project is not located in an area in which the num-
ber and nature of the existing sources already in the area
are such that existing, background air quality cannot []
reasonably be determined with sufficient accuracy to be
protective of the NAAQS without conducting pro-
ject-specific ambient monitoring.
Response to Comments at 74. IEPA does not cite to record evidence supporting this assertion, nor has the Board found supporting evidence in the permitting re- cord. On the contrary, the record shows the presence of multiple emissions sources in the vicinity of the Plant, casting doubt on IEPA’s assertion that the area is generally free from the impact of other point sources. See NAAQS Modeling Inventory (Ex. 7 to Petition) (indicating the presence of 23 emissions sources within 5 miles of the Plant and 61 sources within 10 miles). In light of this evi- dence, the Board, during oral argument, asked counsel for IEPA if the record con- tained any additional support for the use of the Case I criteria, which, as stated above, is not to be used in areas of multisource emissions. See Ambient Monitor- ing Guidelines § 2.4.1 at 6. Counsel for IEPA (Gerald T. Karr) was unable to cite any additional evidence supporting IEPA’s determination.28 Under these circum- stances, IEPA has failed to satisfy its obligation to provide a reasoned and well supported explanation for its determination.
28 The oral argument transcript shows the following exchange between the Board and Gerald
Karr:
JUDGE: The Case [I] example allows for the use of regional monitoring
networks[;] as I understand[,] it is not intended for cases of multi-source
emissions. And what I’m struggling with is that there is data in the re-
cord that Sierra Club has pointed to which would appear to be circum-
stances of multi-source emissions. And I’m looking for how IEPA or
Vulcan responds to that data to show that notwithstanding what would
appear to be multi-source emissions, it’s still appropriate to use the re-
gional monitoring data. And that I think is something that would assist
the Board in its deliberations.
MR. KARR: Okay. And again, I think that the NSR Manual allows the
[IEPA] to use this regional data regardless of the localized data that you
reference. I think it’s just in their discretion to use that and that they have
felt that that was better representative than to address the situation that
arose here.
EAB Oral Arg. Tr. (Dec. 14, 2010) at 37-38.
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 183
Although, as stated above, this Board has upheld the use of non site-specific
regional data where circumstances warrant,29 and the Board will generally defer to the permit issuer’s technical determinations, permit issuers must justify the use of such data and provide “meaningful responses to significant comments that articu- late with reasonable clarity the facts and circumstances supporting the permit is- suers’ decisions.” Northern Mich. Univ., 14 E.A.D. at 328 (remanding permit where permit issuer failed to provide sufficient explanation for using off-site monitors (citing In re Amerada Hess Corp., 12 E.A.D. 1, 14-20 (EAB 2005)); In re Washington Aqueduct Water Supply Sys., 11 E.A.D. 565, 586-90 (EAB 2004); In re Steel Dynamics, Inc., 9 E.A.D. 165, 174-81 (EAB 2000); In re RockGen Energy Ctr., 8 E.A.D. 536, 555-58 (EAB 1999); In re Ash Grove Cement Co., 7 E.A.D. 387, 417-18 (EAB 1997); In re Austin Powder Co., 6 E.A.D. 713, 720 (EAB 1997); In re Tallmadge Generating Station, PSD Appeal No. 02-12, at 8-12, 22-28 (EAB May 21, 2003) (Order Denying Review in Part and Remand- ing in Part)). IEPA’s response, lacking in facts and specificity, falls short of this standard.
The permit is therefore remanded on this issue. On remand, IEPA must
reevaluate whether the use of regional monitoring data was appropriate in this case. Further, if IEPA continues to rely on the use of regional data, IEPA must provide a thorough explanation of how its determination complies with the appli- cable statutory and regulatory provisions and reflects EPA guidance on data rep- resentativeness. See Northern Mich. Univ., 14 E.A.D. at 328. IEPA must also pro- vide the public with an opportunity to review and comment on its determination on remand.
3. Has the Sierra Club Demonstrated That IEPA Clearly Erred in
Setting BACT Limitations for NOx and CO?
As stated above, the permit establishes a BACT limit for CO of 11.48 lb/ton
and a limit of 4.5 lb/ton for NOx. In its comments on the draft permit, the Sierra Club asserted that the 4.5 lb/ton NOx BACT limit was inappropriate because, among other things, EPA’s database containing relevant RACT/BACT/LAER technology determinations indicated that lower emission rates were achievable.30
29 See, e.g., Knauf, 8 E.A.D. at 145-48.
30 “RACT” refers to “reasonably available control technology.” CAA § 172(c)(1), 42 U.S.C.
§ 7502(c)(1). For areas designated as being in “nonattainment” with national ambient air quality stan- dards, states must submit implementation plans that shall, at a minimum, provide for adoption of “rea- sonably available control technology.” Id. “LAER” refers to the “lowest achievable emission rate.” CAA § 171(3), 42 U.S.C. § 7501(3). In areas designated as being in nonattainment with national ambi- ent air quality standards, any permit issued to construct and operate a source must require that the source comply with the “lowest achievable emission rate” for the relevant air pollutant, as measured by the most stringent emission limitation for such class or category of source contained in any state im-
Continued
VOLUME 15
184 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
Sierra Club Comments at 40. In addition, the Sierra Club pointed out that in an October 2000 memo, “IEPA identified a number of facilities achieving a lower NOx emission rate than 4.5 lb/ton.” Id. Similarly, with regard to the proposed BACT limitation for CO, the Sierra Club argued that IEPA’s October 2000 memo showed that lower emissions rates were achievable and that the record contained little support for the permit’s 11.48 lb/ton BACT emissions limit. Id. at 41.
In its Response to Comments, IEPA stated that the NOx and CO emissions
rates were necessary to allow for variation in facility operation and allow the fa- cility to achieve emissions rates over the life of the facility. Response to Com- ments at 65-70.31 Importantly, IEPA states that “[t]he relevant test to establishing NOx BACT limits is the one that was performed on the [Vulcan] kiln itself, when it was historically operated.” Id. at 67. In particular, IEPA refers to stack tests conducted at the Plant in 1999 in which NOx emissions were measured at 3.45 lb/ton. Id. Similarly, IEPA states that 1999 stack tests measured CO emis- sions at 4.76 lb/ton. Id. at 69. IEPA then used these 1999 emission test results for NOx and CO as a baseline from which to establish emissions limits in the current permit. IEPA justifies the increases in the permit’s emissions limitations between the 1999 stack tests and the limitations in the instant permit, as necessary to pro- vide a compliance margin (also referred to as an operating margin or safety fac- tor) that will, according to IEPA, address variations in Plant operation. See id. at 67-70; IEPA Response at 14-15.
On appeal, the Sierra Club argues that there is no basis in the record for the
difference between the actual emissions measured in the 1999 stack tests (3.45 lb/ton for NOx and 4.76 lb/ton for CO) and the emissions limitations in the proposed permit (4.5 lb/ton for NOx and 11.48 lb/ton for CO). The Sierra Club objects to this increase of allowable emissions of NOx by 30% and CO by 240% when compared to the 1999 stack tests for this facility. Petition at 30-35.
The Board recently addressed the issue of compliance margins or safety fac-
tors in some detail. As the Board explained:
(continued)
plementation plan or achieved in practice by other sources in that class or category. Id.; CAA
§ 173(a)(2), 42 U.S.C. § 7503(a)(2).
31 With regard to the October 2000 memo, IEPA stated that the memo is a “historic document
associated with the previous issuance of a revised construction permit” and did not recommend any particular NOx limitation. Response to Comments at 66-67. Although the memo lists test results for other lime plants, IEPA states that the specific circumstances at those plants, such as the type of limes- tone being used, is unknown. Id. at 67. Thus, IEPA states that the listed test results “cannot be corre- lated to the NOx emissions of the proposed Vulcan lime kiln and cannot be used as a basis to set a NOx BACT limit for the proposed kiln.” Id. Similarly, IEPA discounts the value of the October 2000 memo in establishing the permit’s CO BACT limitations. See id. at 67, 70 (stating that the 2000 memo is a “historic document” listing results from facilities whose specific circumstances “are not fully known”).
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 185
[P]ermit writers retain discretion to set BACT levels that
“do not necessarily reflect the highest possible control ef-
ficiencies but, rather, will allow permittees to achieve
compliance on a consistent basis.” In re Steel Dynamics,
Inc., 9 E.A.D. 165, 188 (EAB 2000); accord In re Three
Mountain Power, LLC, 10 E.A.D. 39, 53 (EAB 2001). In
particular, we have approved the use of a so-called “safety
factor” in the calculation of the permit limit to take into
account variability and fluctuation in expected perform-
ance of the pollution control methods. See, e.g.,
[In re Knauf Fiber Glass, GmbH, 9 E.A.D. 1, 15 (EAB
Mar. 14, 2000) (“Knauf II”)] (“There is nothing inherently
wrong with setting an emissions limitation that takes into
account a reasonable safety factor.”). As we noted in
[In re Masonite Corp., 5 E.A.D. 551 (EAB 1994)], where
the technology’s efficiency at controlling pollutant emis-
sions is known to fluctuate, “setting the emissions limita-
tion to reflect the highest control efficiency would make
violations of the permit unavoidable.” 5 E.A.D. at 560.
In essence, Agency guidance and our prior decisions rec-
ognize a distinction between, on the one hand, measured
“emissions rates,” which are necessarily data obtained
from a particular facility at a specific time, and on the
other hand, the “emissions limitation” determined to be
BACT and set forth in the permit, which the facility is
required to continuously meet throughout the facility’s
life. Stated simply, if there is uncontrollable fluctuation or
variability in the measured emission rate, then the lowest
measured emission rate will necessarily be more stringent
than the “emissions limitation” that is “achievable” for that
pollution control method over the life of the facility.
In re Russell City Energy Ctr., 15 E.A.D. 1, 58-59 (EAB 2010) (quoting In re Newmont Nev. Energy Inv., LLC, 12 E.A.D. 429, 441-42 (EAB 2005)).
In determining whether the selection of a compliance or safety margin is
appropriate, the Board’s analysis is fact- and case-specific. See Russell City, 15 E.A.D. at 80 (citing In re Prairie State, 13 E.A.D. 1, 55 (EAB 2006) (explain- ing that the “appropriate application of a safety factor in setting an emission limit is inherently fact-specific and unique to the particular circumstances of the se- lected technology, the context in which it will be applied, and available data re- garding achievable emissions limits”)). In each case, the Board will examine the specific facts and circumstances in order to determine if the compliance or safety margin is fully supported by the record and reflects the permit issuer’s considered
VOLUME 15
186 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
judgment.32 Id. at 64-65. While a well-supported compliance or safety margin will generally be upheld by this Board, a compliance or safety margin can cross the line from permissible to impermissible where it is “excessively large or is not sufficiently documented and supported.” Id. Thus, “selection of a reasonable safety factor is not an opportunity for the permittee to argue for, or for the permit issuer to set, a safety factor that is not fully supported by the record, or that does not reflect the exercise of the permit issuer’s considered judgment in determining that the emissions limit, including the safety factor, constitutes BACT.” Id.
In Russell City, this Board upheld a compliance margin for the permit’s NO2
startup emissions limits while recognizing that “it could be argued that the compli- ance margins selected here tend towards the more generous side.” Id. The Board did so, however, noting that the permit issuer had conducted an extensive BACT analysis, including an analysis of data from several other facilities. Id. Upon re- view of that data, the permit issuer concluded that a compliance margin was needed to ensure that emissions limits could be reasonably achieved over time. See id. at 50-51. Although petitioners in that case cited data from other facilities, such as the Palomar Energy Center in California, with lower NO2 startup emis- sions rates, the permit issuer nevertheless determined that a higher limit was ap- propriate for the Russell City facility. The permit issuer in Russell City stated, in part, that:
[T]he data from [the Palomar Energy Center in Califor-
nia] includes only five available data points for cold
starts, which does not generate a great deal of statistical
confidence that the maximum seen in this data set is rep-
resentative of the maximum that can be expected over the
32 As this Board stated in Russell City:
The Board has upheld a range of safety factors, compliance factors,
and/or safety margins. E.g., Newmont, 12 E.A.D. at 459-64 (upholding
the permit issuer’s limit based on a control efficiency of 66.5%, where
reductions of up to 80 to 90% “can be achieved”); [In re Kendall New
Century Dev., 11 E.A.D. 40, 50-54 (EAB 2003)] (upholding permit is-
suer’s selection of 25 ppmvd, even though similar facility has a
20 ppmvd limit); [Steel Dynamics, 9 E.A.D. at 188] (upholding the per-
mit issuer’s decision to use “the most stringent PM limit ever imposed”
on similar facilities, 0.0018, rather than the “lowest ever achieved,”
.0001 grains per standard cubic feet); Knauf II, 9 E.A.D. at 15 (uphold-
ing permit issuer’s use of a 25% safety factor); Masonite, 5 E.A.D.
at 560-61 (upholding permit issuer’s selection of a 95% control effi-
ciency rather than vendor’s proposed guarantee of 97%); In re Pennsau-
ken Cnty., 2 E.A.D. 768, 769-70 (Adm’r 1989) (concluding that 35.7%
removal efficiency rate, as opposed to the 50% rate suggested by peti-
tioners, was not clear error).
Id. at 64.
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 187
entire life of the facility. Moreover, the wide variability in
the data that is available highlights the variability in indi-
vidual startups, underscoring the need to provide a suffi-
cient compliance margin to allow the facility to be able to
comply during all reasonably foreseeable startup scena-
rios. For both of these reasons, the Air District has con-
cluded that a cold startup limit of 480 pounds of NO2 is a
reasonable BACT limit that is consistent with the startup
emissions performance seen at the Palomar facility.
Id. at 50 (quoting permit issuer’s “Additional Statement of Basis”). Upon review, the Board concluded that the compliance margin was rational in light of the evi- dence in the record. As the Board stated:
[The permit issuer] repeatedly emphasized the wide varia-
bility in the facility data, and the record amply supports
these statements. The performance data for cold startups
at Palomar, for example, ranges from 22 to 375 pounds
(or 26 to 435 pounds depending on which air district’s cal-
culations is considered), which is a large range. [The per-
mit issuer] also provided several reasons for the wide va-
riability across sources, as noted above. [The permit
issuer’s] other explanation for its use of a compliance fac-
tor for cold startups – that it only had a small number of
data points – is consistent with the Board’s discussion of
the consideration and significance of long-term data in
Newmont, where the Board explained that “because ‘emis-
sions limitation’ is applicable for the facility’s life, it is
wholly appropriate for the permit issuer to consider, as
part of the BACT analysis, the extent to which the availa-
ble data demonstrate whether the emissions rate at issue
has been achieved by other facilities over the long term.”
12 E.A.D. at 442.
Id. at 63 (citations omitted). The Board concluded that the use of a compliance factor was well-supported and reflected the considered judgment of the permit issuer.
In contrast, the matter before the Board in the present case does not contain
sufficient record support for the use of a compliance margin for emissions of ei- ther NOx or CO. Unlike Russell City, the BACT analysis in this case33 does not
33 See Updated Best Available Control Technology Analysis, Vulcan Construction Materials,
LP, Manteno, Illinois (Nov. 14, 2008) (Ex. F to Vulcan’s Response).
VOLUME 15
188 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
include any discussion of what an appropriate compliance margin should be and why the margin should be set at a particular level. Indeed, the BACT analysis makes no mention of the need for a compliance margin in establishing the per- mit’s NOx or CO emissions limits. Nor does the analysis sufficiently assess data from other facilities which might support the proposed compliance margin. IEPA’s only justification for the compliance margins in this case is contained in IEPA’s responses to comments. Those responses, however, contain only a cursory and unpersuasive explanation for a compliance margin.
For example, in its comments on the draft permit, the Sierra Club argued
that the NOx emissions rate was inappropriate. The Sierra Club pointed out that a search of EPA’s RACT/BACT/LAER clearinghouse revealed NOx emissions rates at other plants lower than the 4.5 lb/ton NOx emissions rate in the instant permit. Sierra Club Comments at 38. In its response, IEPA stated that the Sierra Club comment failed to consider factors resulting in differences in achievable NOx rates at plants, such as Vulcan’s, processing lower calcium, dolometic limestone. Response to Comments at 65-66. According to IEPA, such differences result in a higher NOx emissions rate than at other lime kilns processing high calcium limes- tone. Id. at 66. While this may be true, it does little to explain the size of the particular compliance margin chosen in this case. As IEPA has stated, results from 1999 stack tests at the Vulcan Plant showed substantially lower NOx emis- sions rates were achievable. Presumably, the Plant was processing the same low-calcium, dolometic lime during the 1999 stack test as proposed in the current permit. See Project Summary at 2 (stating that the facility uses dolometic limes- tone reserves from an adjacent quarry).
IEPA states further that the higher emission limits in the instant permit are
necessary to address variations in Plant operation. IEPA Response at 14-15. Re- sponse to Comments at 66-70. In particular, with regard to NOx emissions, IEPA stated, in part, as follows:
The NOx emissions of the kiln measured by this test were
3.45 pounds per ton of stone feed. The various limits for
NOx set as BACT all relate to this solid reference point
for the NOx emissions of the proposed kiln. At least ini-
tially, a limit higher than the tested emission rate must be
set to provide an operating margin to address normal vari-
ation in the operation of the kiln.
Response to Comments at 67 (footnotes omitted). With regard to CO emissions, IEPA stated that “[a]s CO is controlled by good combustion practices, it is appro- priate for the CO BACT limit to be set with a significant margin of compliance to address normal variability in operation. Accordingly, the BACT limit is set at 11.48 pounds per ton.” Id. at 69. Aside from these conclusory assertions that a margin of compliance is appropriate, the only other explanation IEPA provides is
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 189
that the selected margins of compliance are necessary to account for the “conflict- ing relationship between NOx and CO emissions during combustion processes and the BACT determination for NOx.” Id. at 69-70. That is, IEPA states that any practices designed to reduce NOx will be accompanied by an increase in CO emis- sions. Id. Presumably, however, this “conflicting relationship” between NOx and CO existed at the time the 1999 stack tests were conducted. Nevertheless, the 1999 test results showed a NOx emission rate of 3.45 lb/ton and a CO emission rate of 4.76 lb/ton. Moreover, this inverse relationship does little to explain why IEPA selected the specific NOx and CO limitations at issue in this case. IEPA provides no other explanation or data supporting a margin of compliance, nor does it provide any data or analysis supporting the size of the compliance margin.34
As stated above, while the Board generally upholds a well-supported com-
pliance or safety margin, the record must contain a sufficient explanation and jus- tification for the permit issuer’s determination to include a margin as well as its size. IEPA’s failure to include an explanation in its BACT analysis and its con- clusory statements in responding to comments on this issue are insufficient. IEPA fails to provide an adequate rationale as to why a compliance margin is appropri- ate in this case. Significantly, even if IEPA had established the need for a compli- ance margin, the record is wholly devoid of an explanation for the 30% margin for NOx or the 240% margin for CO.35 While there may be valid reasons for in- cluding compliance margins, IEPA has failed to sufficiently articulate those rea- sons or to provide the necessary record support. Under these circumstances, as Russell City clearly stated could occur, see Russell City, 15 E.A.D. at 65, the com- pliance margin in this case crosses the line from permissible to impermissible. Thus, the limitations cannot be justified as BACT on this record. The permit is therefore remanded on this issue. On remand, IEPA must either provide a suffi- cient rationale for including a compliance margin for NOx and CO, as well as a sufficient rationale for the size of any such margins, fully consistent with the
34 In its Response to Comments, IEPA also states that the permit’s CO emissions limits are
“consistent with recent CO BACT determinations for certain new lime kilns. In particular, the equivalent CO emission factors represented by the BACT limits set for [two new] lime kilns proposed by Graymont (PA), Inc., at its plant in Bellefonte, Pennsylvania, are 13.25 and 19.0 pounds per ton.” Response to Comments at 69. IEPA, however, provides no analysis as to whether these sources are representative of the current facility or whether the emissions from these sources are set at a level that is higher or lower than other similar facilities. Further, because IEPA does not make clear what the NOx limits are in these new lime kilns, the Board is unable to determine how the conflicting relation- ship between CO and NOx operates in those cases.
35 When confronted at oral argument with the lack of record support for the size of the compli-
ance margins for either NOx or CO, counsel for IEPA stated: “I guess I would just say that that’s the analysis that [IEPA] developed based on the data they had with the idea that you want a setback at a level that’s consistently achievable. You don’t want to have them constantly going up and over the limits.” EAB Oral Arg. Tr. at 42-43. This conclusory assertion is hardly the type of justification con- templated by the Board in Russell City in selecting the actual margin in a particular case.
VOLUME 15
190 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
Board’s precedents, or remove the compliance margins from the permit. Should IEPA choose to retain compliance margins, it must reopen the public comment period to provide the public with an opportunity to submit comments.36
4. Application of New One-Hour Primary NAAQS for Nitrogen
Dioxide
On February 9, 2010, EPA published in the Federal Register a final rule
revising the primary NO2 NAAQS “in order to provide requisite protection of public health as appropriate under section 109 of the Clean Air Act.” 75 Fed. Reg. at 6475. This rule set the new 1-hour NO2 NAAQS standard at 100 ppb to supple- ment the existing annual standard. The new standard became effective on April 12, 2010, one business day after IEPA issued the permit in this case.
On appeal, the Sierra Club argues that IEPA should have applied the new
standard in this case because the permit did not become final on the date IEPA issued the permit (April 9, 2010). In particular, the Sierra Club argues that:
pursuant to 40 C.F.R. § 124.15(b), the permit does not be-
come final until “30 days after the service of notice of the
decision” unless an appeal is filed with the Board, in
which case the final permit is issued when the Board de-
nies review, decides the case on the merits without a re-
mand, or upon completion of remand proceedings after
the Board’s review (unless the Board notifies the parties
that appeal after the remand is required to exhaust reme-
dies). 40 C.F.R. § 124.19(f)(2). Here, there is no question
that the permit decision could not have become final, even
absent this appeal, until at least May 9, 2010. There is
also no question that the effective date for the 1-hour NO2
NAAQS occurred before the final permit was issued.
Therefore, IEPA had a clear obligation to ensure that the
[Plant] would not cause or contribute to a violation of the
1-hour NO2 NAAQS. 42 U.S.C. § 7475(a)(3), (e)(1);
40 C.F.R. § 52.21(k)(1), (m).
Petition at 36. In response, IEPA asserts that this issue was not raised during the comment period and was therefore not preserved for review. IEPA Response at
36 On remand, if IEPA determines based on the record that the use of compliance margins is
appropriate in this case, the Board encourages IEPA to carefully review the Board’s case law, includ- ing Russell City, as to the level of analysis and documentation required to support such a determina- tion, including the importance of carefully evaluating multiple sources and data points as well as infor- mation such as recent permit limits at other similar facilities.
VOLUME 15
VULCAN CONSTRUCTION MATERIALS, LP 191
15-16. IEPA states further that a permit issuer is only required to apply the law in effect on the date a permit is issued, in this case April 9, 2010, and is under no legal obligation to retroactively apply new regulations. Id. at 16.
As this Board has stated, for purposes of determining the applicability of
new rules or guidance, a permit is “issued” when the permit issuer makes its final permit decision pursuant to 40 C.F.R. § 124.15(a). See Russell City, 15 E.A.D. at 81 n.100 (“[u]nder EPA’s procedural regulations, a permit is ‘issued’ when the Regional Office makes a final decision to grant the application, not when the per- mit becomes effective or final agency action.”) (quoting Office of Air & Radia- tion, U.S. EPA, PSD and Title V Permitting Guidance for Greenhouse Gases at 3 n.6 (Nov. 2010)). Thus, because IEPA issued its permit decision in this case on April 9, 2010, before the effective date of the new one-hour NO2 standard, IEPA was not required to ensure compliance with the NO2 standard. Review is therefore denied on this issue.37
VII. ORDER
The permit is remanded. On remand, IEPA must: (1) Prepare a revised
BACT analysis for PM2.5 and reopen the public comment period to provide the public with an opportunity to review and comment on this analysis;38 (2) Reevalu- ate whether the use of regional monitoring data was appropriate in this case;39 and (3) Either provide a sufficient rationale for including a compliance margin for NOx and CO, as well as the size of any such margins, or remove the compliance margins from the permit.40
37 Because review is denied on this issue, the Board does not reach the issue of whether the
Sierra Club properly preserved the issue for review.
38 As stated above, EPA has proposed a repeal of the grandfathering provision. On remand, if
applicable rules allow IEPA to continue to rely on a surrogacy analysis, IEPA must, consistent with the Administrator’s decision in Louisville Gas, provide a sufficient, detailed, and well-supported basis for its conclusion that, in the particular circumstances of this permit, PM10 is a reasonable proxy for PM2.5. If applicable rules prevent IEPA from relying on such an analysis, IEPA must conduct an ade- quate top down BACT analysis for PM2.5. In either case, IEPA must reopen the public comment period and provide the public with an opportunity to submit comments.
39 Upon completion of this reevaluation, IEPA must reopen the comment period and provide
the public with an opportunity to submit comments.
40 Should IEPA choose to retain the compliance margins, it must reopen the comment period
and provide the public with an opportunity to submit comments.
VOLUME 15
192 ENVIRONMENTAL ADMINISTRATIVE DECISIONS
After IEPA completes its analysis on remand and issues its final permit de-
cision pursuant to 40 C.F.R. § 124.15(a),41 anyone dissatisfied with IEPA’s deci- sions must file a petition seeking the Board’s review in order to exhaust adminis- trative remedies pursuant to 40 C.F.R. § 124.19(f)(1)(iii). Any such appeal shall be limited to issues addressed by IEPA on remand.
So ordered.
41 The Board’s decision in this case includes a broad remand on significant and foundational
issues, including the BACT and air quality analyses, and it will require a reopening of the comment period and reissuance of the permit. Under the facts of this case, where the significant issues to be addressed on remand will necessitate reopening the comment period, IEPA must comply with all ap- plicable standards in effect at the time the permit is issued on remand. In re Shell Gulf of Mexico, Inc.
& Shell Offshore, Inc., 15 E.A.D. 103, 150-51 n.76 (EAB 2010); In re Shell Gulf of Mexico, Inc. & Shell Offshore, Inc., OCS Appeal No. 10-01 through 10-04, at 19-25 (EAB Feb. 10, 2011) (Order on Motions for Reconsideration and/or Clarification) (“Clarification Order”). Since EPA has authority to lawfully exercise, “through an appropriate process, any discretion it has to interpret what ‘all applica- ble standards in effect’ means to a particular source being permitted,” Clarification Order at 24, IEPA should confer with the EPA as to whether EPA plans to exercise any such discretion that would affect Vulcan.
VOLUME 15
Does this precedent still control your case?
Ezel checks whether it still stands, including any court review since, and applies it to your situation with citations.
Opens in Ezel Pro.
- Checks the law as it stands today, not only this page
- Cites every source it relies on, so you can verify it
- Chat, drafting and research in one workspace